Aircraft Fire Extinguishing Systems
From SKYbrary Wiki
|Category:||Fire Smoke and Fumes|
|Content control:||Air Pilots|
Onboard systems designed to extinguish fires which occur either in the air or on the ground.
For information on detecting and fighting fires in the cabin, see also the separate article: "Passenger Cabin Fire"
Four types of fire extinguishing installations are found on commercial transport aircraft.
- Portable Extinguishers installed at specified locations in both the main cabin and the flight deck
- Hold fire extinguishing systems (with automatic detection)
- Engine fire bottle extinguishing systems (with automatic detection)
- Toilet waste bin bottle extinguishing systems
Fires on board aircraft which occur within the aircraft cabin or flight deck - or are potentially directly accessible from them - arise in one of three ways:
- Fires that involve energized electrical equipment - in aircraft cabins typically IFE (In Flight Entertainment) systems in the passenger cabin, electrical equipment in the galley or avionics equipment in the flight deck or under floor avionics bay, or Personal Electronic Devices (PEDs) carried by passengers.
- Fires in ordinary combustibles such as cloth, paper, rubber, and many plastics - in aircraft cabins typically in furnishings
- Fires in flammable liquids, oils, greases, tars, oil-base paints, lacquers, and flammable gases - in aircraft cabins typically galley oven fires
Portable extinguishers present a special challenge since they must be capable of extinguishing a range of fire types - solid materials such as cabin fixtures and furnishings, flammable liquids and electrical fires.
Halon 1211 extinguishers have entirely replaced the previous combination of two different types of portable extinguisher - Carbon Dioxide and Water Glycol - on new-build aircraft and no other single extinguisher-type has yet been identified as a satisfactory alternative to it.
NOTE: Crews must be aware that the toxicity of the Halon gases, especially the combination which makes up Halon 1211, is such that use in confined spaces requires care to minimize any inhalation of the discharged gases. Where a portable Halon extinguisher is used by cabin crew, it is usually recommended to consider donning a smoke hood before discharge to eliminate this risk, but for flight crew use on the flight deck, this will not be an option and risk awareness is the only defence.
Where the dual fit of extinguisher is encountered on older aircraft, it is essential that Water Glycol extinguishers are used on solid material fires and Carbon Dioxide extinguishers on liquid or electrical equipment fires.
The minimum dispatch requirement for aircraft portable fire extinguishers is determined by the capacity of the aircraft cabin and is specified in the Aircraft MEL.
- Minimum number of hand held fire extinguishers to be carried on board. This depends on the size of the aircraft, the number of passenger seats, the number and type of cargo compartments, etc.
- Hand held fire extinguisher distribution within the aircraft (e.g. number of extinguishers in the cockpit, cabin, cargo compartments, etc.).
- Mounting and marking (e.g. there should be a special sign in case the fire extinguisher is not clearly visible).
- The need for regulatory approval and acceptable means of compliance.
- Restrictions regarding the extinguishing agents used (e.g. cut-off and end dates for Halon-based extinguishers).
- Extinguishing agent quantity requirements (e.g. minimum amount of agent per extinguisher).
- Health considerations (e.g. toxic gas hazard minimization).
Hold Fire Extinguishing Systems
Hold fire extinguishing systems are usually activated as a flight crew response to abnormal heat detection in an aircraft hold, and usually operate in a dual function. Part of the available fire suppression capability is deployed in an ‘instant’, or ‘knock-down’, discharge of extinguishing agent and the remainder is deployed more gradually over a longer period of up to an hour, to assist in preventing re-ignition or at least providing partial fire suppression, to provide more time to get an aircraft with a continuing hold fire warning back on the ground. Various alternatives to Halon 1301 have been examined including water misting, inert gas and dry powder, either alone or in combination. The FAA has developed minimum performance standards for these systems and it has been demonstrated that although water misting alone is unable to pass the exploding aerosol can fire test, a combination of water misting and inert gas (nitrogen) discharge may be more effective. However, for such a solution to be viable, a means of on-board nitrogen generation will be needed.
Engine Fire Bottles
Fire Bottles in engine compartments are usually electrically operated after manual selection by the flight crew based upon automatic fire detection. In the airborne case, APU fire bottles are similarly activated but it is usual for automatic APU fire detection during ground operation to trigger automatic shutdown and fire extinguisher activation. Until recently, the most common extinguishing agent was Halon 1301 for all Engines/APUs fitted to civil transport aircraft. However, Halon 1301 is no longer manufactured and has been banned (for new systems) since 1994; often they are now replaced by HFCs (Hydrofluorocompounds).
Toilet Waste Bins
Toilet waste bin fire extinguishers are activated automatically if heat detectors in the vicinity are activated. Toilet Smoke detector activation does not trigger waste bin fire extinguishers. Alternative extinguishing agents to Halon 1301 have been approved for use in fixed toilet waste bin systems and have also been, uniquely in terms of the search for Halon alternatives, shown to be more effective than Halon 1301 units whilst being the same size. Since only a documentation change is required to fit these alternative extinguishers, they have been used for retrofit as well as in new-build aircraft.
Personal Electronic Devices
Equipment has been introduced designed to deal specifically with lithium battery fires in PEDs; Lithium ion batteries (Li-ion) are used to power PEDs such as cellular phones, portable tablets, EFBs and digital cameras; Li-ion batteries are rechargeable. Non-rechargeable lithium batteries (Li-metal) are similar to Li-ion, but use a different electrode material – metallic lithium.
All lithium batteries present a potential fire hazard. These batteries are carried on aeroplanes as cargo, within passenger baggage, and by passengers directly. Like some other batteries lithium batteries are capable of delivering sufficient energy to start an in-flight fire. Lithium batteries present a greater risk of an in-flight fire than some other battery types because they are also unable to contain their own energy in the event of a catastrophic failure.
Once extinguished, a lithium battery fire – or a fire in a PED powered by lithium batteries – requires containment and continued cooling. Halon 1211 or water fire extinguishers are effective at extinguishing the fire and preventing its spread to additional flammable materials. After extinguishing the fire, dousing the electronic device with water or other non-alcoholic liquids cools the device and prevents additional battery cells from reaching thermal runaway. Containment devises are now available and where these are equipped, crews should receive specific training in how to use them to greatest effect.
These issues are discussed in some detail in the RAeS document "Smoke, fire and fumes in transport aircraft, past history, current risks and recommended mitigations - Part 1:References". See also the separate articles: "Aircraft Fire Risk from Battery-powered Items Carried on Aircraft" and 'Personal Electronic Device Fire - Cabin Crew Checklist".
Accidents and Incidents
Hand held extinguisher used
- DC93, en-route, Cincinnati OH USA, 1983 (On 2 June 1983, a DC9 aircraft operated by Air Canada was destroyed following an in-flight fire which began in one of the aircraft’s toilets. 23 passengers died in the accident.)
- B744, Phoenix USA, 2009 (On 10 January 2009, a Boeing 747-400 being operated by British Airways on a scheduled passenger flight from Phoenix USA to London had been pushed back from the gate in normal daylight visibility and the engines start was continuing when fumes and smoke were observed in the cabin and flight deck. The aircraft commander decided to return to the stand but there was some delay while the tug was reconnected and the movement accomplished. The intensity of the fumes increased and as the aircraft came to a halt on the stand an emergency evacuation was ordered.)
- B738, en-route, Colorado Springs CO USA, 2006 (B738 diversion into KCOS following in-flight fire. The fire started after a passenger's air purifier device caught fire whilst in use during the flight. The user received minor burns and the aircraft cabin sustained minor damage.)
- A320, vicinity New York JFK NY USA, 2007 (On 10 February 2007, smoke was observed coming from an overhead locker on an Airbus A320 which had just departed from New York JFK. It was successfully dealt by cabin crew fire extinguisher use whilst an emergency was declared and a precautionary air turn back made with the aircraft back on the ground six minutes later. The subsequent investigation attributed the fire to a short circuit of unexplained origin in one of a number of spare lithium batteries contained in a passenger's camera case, some packaged an some loose which had led to three of then sustaining fire damage.)
- Halon Fire Extinguishers
- In-Flight Fire: Guidance for Flight Crews
- Passenger Cabin Fire
- Aircraft Hold Fire Risks
RAeS and Air Pilots The Royal Aeronautical Society and Honorable Company of Air Pilots jointly revised and re-issued valuable reference documents on this topic, which should be used as first references for flight crew on this topic:
- Smoke, fire and fumes in transport aircraft, past history, current risks and recommended mitigations - Part 1:References, Fifth Ed., 2018, Royal Aeronautical Society.
- Smoke, fire and fumes in transport aircraft, past history, current risks and recommended mitigations - Part 2:Training, Second Ed., 2018, Royal Aeronautical Society.
- AC 20-42D: Hand Fire Extinguisbers for use in Aircraft, January 2011
- Effectiveness of Hand-Held Extinguishers Against Hidden Cabin Fires
- Laptop Computer Fire Extinguishment
- Lithium batteries: safe to fly?, C. Bezard et al., Airbus Safety First No. 21, pp. 22-41, January 2016